Air Guyed Tower Kit
27 feet - Model 1‐TWA‐10‐01
45 feet - Model 1-TWA-10-02

Includes Couplers, Guy Wires and Hardware. Poles not included.

Product Application:
To be used with the Air-X Wind Turbines Only.

Product Benefits:
• Install in a few hours
• No concrete
• No winching
• No sweat!

____________________________________________________________

Model 1‐TWA‐10‐01 - 27 Feet Air Guyed Tower Kit

27 Feet Kit includes:
• Base Connector
• Lower Wire Set (160 ft. pre-cut)
• Base Staples (2)
• 3/8" x 1 œ" Bolts (2)
• 3/8" Locknut (2)
• Cable Thimbles (4)
• Cable Clamps (8)

Pipe Pieces Needed (available at fence suppliers)
• 24 ft (7.2 m) length for tower
• 3 ft (9 m) length for tower
• 6 ft (1.8 m) length for tower base

27 Feet Kit PIPE REQUIREMENTS Tower Kits use 1-7/8 inch (47.5 mm) Steel Tubing
Maximum Wind Speed	Recommended Wall Thickness	Pipe Schedule
90 mph	.065 inch (1.65 mm)	n/a
100 mph	.090 inch (2.3 mm)	Schedule 20
120 mph	.140 inch (3.6 mm)	Schedule 40

Download PDFs » 

Air-X 27 feet Guyed Tower Manual
Air-X 27 feet Guyed Tower Analysis
____________________________________________________________

Model 1‐TWA‐10‐02 -  45 Feet Air Guyed Tower Kit

45 Feet Kit includes:
• Base Connector
• Upper Wire Set (280 ft. pre-cut)
• 2 Lower Wire Set (160 ft. pre-cut)
• Base Staples (3)
• 3/8" x 1 œ" Bolts (3)
• 3/8" Locknut (8)
• Cable Thimbles (16)
• Cable Clamps 1*

45 Feet Setup Kit:
* Note: This 45 foot Tower Kit includes a setup kit to raise the tower.  If more than one tower is to be erected, a single setup up kit can be used for any towers to be installed.  See below for kit details.

45 Setup Kit includes:
• Gin Pole Cap
• 100 Foot Rope
• Snap Links (3)
• 8 Foot Cable
• 3/8" x 1-1/2" Bolt
• 3/8" Locknut

Pipe Pieces Needed (available at fence suppliers)
• 24 ft (7.2 m) length for tower
• 21 ft (6.3 m) length for tower
• 6 ft (1.8 m) length for tower base
• 21 ft (6.3 m) length for gin pole

45 Feet Kit PIPE REQUIREMENTS Tower Kits use 1-7/8 inch (47.5 mm) Steel Tubing   Maximum Wind Speed
Maximum Wind Speed	Recommended Wall Thickness	Pipe Schedule
70 mph	.065 inch (1.65 mm)	n/a
80 mph	.090 inch (2.3 mm)	Schedule 20
90 mph	.140 inch (3.6 mm)	Schedule 40

Download PDFs » 

Air-X 45 feet Guyed Tower Manual
Air-X 45 feet Guyed Tower Analysis

____________________________________________________________

Guyed Tower Anchor Recommendations
There are four types of anchors that are most commonly used with our towers, screw in "Auger" type anchors, hammer driven "duckbill" anchors, cast concrete anchors and expansion bolts (for use only in solid rock). What anchor should be used depends on the soil type that the anchors will be placed in. See the following table for our suggestions.

AIR towers are PE stamped and approved for California buy-down program. Contact us for tower plans and wet seal stamps at additional costs.

____________________________________________________


HELP » Contact Customer Support 
• Toll-Free help line offering sizing support
• Online e-mail technical and installation support

____________________________________________________

*Shipping Cost:
Shipping amounts may vary due to fluctuations in the transportation industry. Final shipping costs may need to be adjusted during order processing. If there is a change in the total shipping cost you will be contacted for approval before the order is finalized.

Processing and Delivery Information: Please allow Processing Time as stated above for your order, plus standard transportation delivery time. Orders placed after 2PM EST may not begin processing until the next business day. Please call for Rush Processing and/or Rush Shipping options.

This product is non-refundable.